Portable clamp set with self-testing clamp

Newson Gale Bond-Rite EZ

The Bond-Rite EZ is an easy to use, portable set of clamps with a self-testing clamp, which quickly and safely verifies the equalisation and earthing connections, e.g. when transferring flammable products.

Technical data

sharp teeth to ensure that the clamp breaks through a layer of rust, paint, glue, resins, grease,
quick-connector for easy disconnection of the clamp from the cable to replace batteries outside the explosion hazard zone,
system powered by a 9-volt battery built into the clamp,
the system can be used for up to 6 hours per day.

Electrostatic Earthing – the offer

Earthing control systems

Earth control systems
with process lock (tanks, big bags)

You can use them in the field of earthing monitoring of e.g. road tankers, railways, big-bags, as well as components of process plants. Earth-Rite systems verify easily and safely that the stored loads are properly discharged to the ground through a monitoring unit with a signal lightning diode. If the earthing is not performed properly, the controllers block the process.

Multiple elements earthing control system

Multiple elements
earthing control system

The MULTIPOINT II system is a device designed to control the earthing of up to 8 self-acting or interconnected system components at the same time. According to the guidelines of international standards for the control of unwanted static discharges, the correctness of earthing will only be confirmed by the system if the resistance of the earthing node on each channel is less than 10 Ω.

Clamps with earthing control

Clamps with earthing control
(IBC tanks, drums, big-bags)

We can offer you clamps with monitoring the state of earthing of barrels, tanks, etc. These solutions, in addition to earthing the equipment operating in production rooms, by means of a monitoring unit with a signalling diode, easily and safely verify that the charges accumulated on the equipment are properly discharged to earth.

Simple earthing clamps for single- and two-core cables

Clamps,
wires, spools

Earthing clamps can be used in two configurations – as a set of two simple clamps connected with each other by a spiral cable, or as a connection of the clamp to a earthed container and a ring clamp, which is located at the end of the cable, to a earthing strip.

Shoe inspection stations Ex ATEX

Shoe inspection
stations Ex ATEX

The electrified human body is one of the most serious sources that pose a fire or explosion hazard in industrial conditions. An example of a solution that checks footwear for its ability to dissipate electrostatic charges before an employee enters an area with flammable atmospheres is the Sole-Mate shoe control system.

Secure your industrial plant

Completed projects

A multi-stage project to stringent requirements or the supply of Ex-rated earthing

A multi-stage project to stringent requirements or the supply of Ex-rated earthing, lighting and electrical engineering systems for an R&D centre

Grounding of road tankers equipped with pump distribution systems

Grounding of road tankers equipped with pump distribution systems – how to block the product transfer in the case of lack of proper grounding

Supply of grounding control systems for process installations, road tankers and drums and tanks

Supply of grounding control systems for process installations, road tankers and drums and tanks

Furnishing of 9 tanker unloading stations at a new power unit with earthing control systems

Enhancing the safety level at the flour manufacturer’s plants by selecting appropriate systems for earthing road tankers and dump trucks

Supply of earthing systems for the new plant of a construction chemicals manufacturer

Delivery of modified ground control systems of tankers with additional automation systems

Supply of earthing system for a printing machine

Delivery of Electrostatic Earthing Systems for a Pharmaceutical Plant as Aimed at Adapting Production Facilities to the ATEX Requirements

Successive deliveries of electric grounding and bonding systems for the largest manufacturers of plastic film packaging

Lighting Fittings and a Hydrogen Detection System for a Submarine

How did we resolve problem of electrostatic discharges in the paint and varnish industry

Over a Dozen of Earthing Control Systems for a Manufacturer of Eyeglass Lenses

Electrostatic Earthing Systems for a Manufacturer of Paints and Varnishes

Earthing controllers for a leading packaging manufacturer

Knowledge base

A mistake in the EPD, or a deliberate act? Or how additional costs arise.

Protection of a bucket elevator

Explosion suppression and isolation system for a bucket elevator: how to blast proof a brewery

Designation of dust explosion hazard zones

Designation of dust explosion hazard zones — introduction

VIDEO – explosion in a vacuum cleaner showing what can happen in an industrial central vacuuming, dust extraction or cyclone systems

FILM – Electrostatic discharge resulted in ignition and explosion of the vapours of flammable liquid stored in IBC container. Fire broke out. The reason was lack of earthing

Dust-mixer-in-which-the-explosion-occurred

Case study — dust explosion in the mixer, causes and effects

Steam Fire Extinguishing in Commercial Power Engineering

Explosion relief – panels versus valves Advantages and limitations

EVN explosion relief valves

EVN explosion relief valves as a reliable protection of industrial plants and equipment

Fire on a conveyor belt transporting petroleum coke

Fire on a conveyor belt transporting petroleum coke

Investment in Dust Collection Systems – How to Set about It?

explosion isolation

A compendium of knowledge on explosion isolation

Dangerous GLUTEN – we do not know if it is bad for you, but it is certainly explosive [Check your product]

Explosion safety when using lead-acid batteries

VIDEO — a case study which accurately shows causes and effects of aluminium dust explosions

decompression_vs_flameless

Decompression panels vs. flameless explosion relief: which one should be chosen?

Explosive coal and biomass in power sector

Explosive coal and biomass may be the next problem for the power sector in the autumn

ATEX Lighting – how to reduce costs

VIDEO – powerful electrostatic discharge during conveyor belt operation. How to calculate the energy of an electrostatic spark?

protect a wastewater treatment plant against a dust explosion

How to protect a wastewater treatment plant against a dust explosion? Analysis with example

hydrogen explosion is gas distributor

7 things you can do to minimise the risk of hydrogen ignition caused by electrostatic discharge

VIDEO – how an explosion occurs during the mixing and pouring flammable liquids. A video depicting real-life events

Explosion Risk Assessment for the Design Stage of a Plant as Exampled by the Company Lajkonik Snacks Sp. z o.o.

Explosion risk assessment and the problems of ensuring safe production in explosion hazard conditions

VIDEO – isobutane leak led to explosion and fire at ExxonMobil refinery

VIDEO – mistaken mixing of liquids in the factory led to the formation of a war gas

[“Rzeczpospolita” daily] – We are building a safe industry

cryogrinding

What you should know about cryogrinding?

Some theory – what is SIL

A sugar dust explosion in an enclosed conveyor caused by many years of neglect

Measure a factory – process systems inventory survey

Explore the advantages and limitations of explosion protection

Explore the advantages and limitations of explosion protection – a practical guide

Explosion at the Kronospan plant

Explosion at the Kronospan plant in Strzelce Opolskie

VIDEO – road tanker fire – probable cause was electrostatic discharge

VIDEO – road tanker fire – probable cause was electrostatic discharge

A dust explosion at the mill completely destroyed the plant

A dust explosion at the mill completely destroyed the plant

explosion in two tanks connected by a channel

Explosion of paracetamol-based dust and its propagation to an adjacent tank. The secondary explosion is even more dangerous than the primary one

[Case study] Dust cloud ignition caused by static electricity

A costly problem with explosive atmospheres – how to avoid it?

A tragic flour explosion

A tragic flour explosion

Explosion pressure wave as a simple and effective form of protection or a few words about the SNR non-return flap

Selection of Anti-explosive Protections – Dedusting and Central Vacuum Systems

Failure to follow proper handling procedures and ensure proper earthing systems can lead to disaster

Electrostatic discharge as a cause of explosion

Marking of Equipment Designed for Use in Potentially Explosive Atmospheres

silo dust monitoring

Is silo dust monitoring an effective solution in explosion prevention?

How to Stop an Explosion – Explosion Decoupling Systems

Fire risk in a waste sorting station. Why and what protection should be used?

Report of the installation of optical fibre temperature detectors on belt conveyors in Dalkia Poznań ZEC

Electrostatic Charge Control in Explosion Risk Zones

Do you have any questions?

Donat Czapski Grupa WOLFF zdjecie

DONAT CZAPSKI - I am at your disposal

+48 695 244 220

info@grupa-wolff.com

We will answer questions about: offer, technical specification, delivery, assembly.

or send your inquiry